Previous Articles    

Study on optimization of the extraction of protamine from Takifugu Flavidus

  

  1. (1 Fisheries Research Institute of Fujian, National Research and Development Sub-center of Marine Fish Processing Technology (Xiamen), Key Laboratory of Cultivation and High-value Utilization of Marin Organisms in Fujian Province, Fujian Collaborative Innovation Center for Exploitation and Utilization of Marine Biological Resources, Xiamen 361013, Fujian, China;
    2 College of Biological Science and Technology, Minnan Normal University. Zhangzhou 363000, Fujian, China)
     
  • Online:2019-06-05 Published:2019-04-20

菊黄东方鲀鱼精蛋白提取工艺优化研究

  

  1. （1福建省水产研究所，国家海水鱼类加工技术研发分中心（厦门），福建省海洋生物增养殖与高值化利用重点实验室，
    福建省海洋生物资源开发利用协同创新中心，福建 厦门 361013；
    2 闽南师范大学生物科学与技术学院，福建 漳州 363000）
  • 通讯作者: 刘智禹（1972—），男，教授级高级工程师，研究方向：水产品加工及质量安全。E-mail: negroliu@163.com
  • 作者简介:刘淑集（1981—），女，助理研究员，研究方向：水产品加工及海洋生物活性。E-mail: cute506636@163.com
  • 基金资助:
    福建省省属公益类科研院所基本科研专项（2018R1003-2）；福建省种业创新与产业化工程项目（2017FJSCZY03）;福建省渔业结构项目调整专项（2017HYJG08、2017HYJG07）；福建省海洋高新产业发展专项（闽海洋高新[2016]07）

PDF (PC)

Abstract: To study the preparation technology of protamine of Tetraodontidae, a single factor experiment was conducted to analyze the effect of NaCl solution pH, H2SO4 concentration, H2SO4 volume, extraction temperature, extraction time and ethanol volume on extraction rate of protamine, with testis of Takifugu Flavidus as raw material and extraction rate of protamine as index. Based on the above basis, the response surface methodology was used to optimize the extraction conditions of protamine. The results showed that after optimization with response surface methodology, the optimal extraction conditions for protamine of Tetraodontidae were NaCl solution pH 8.5, H2SO4 concentration 0.6 mol/L, H2SO4 volume 4 times, extraction temperature 45℃, extraction time 2.4 h and ethanol volume 4 times. Under these conditions, the extraction rate of protamine was up to 19.07%. The study showed that the proposal of optimizing the protamine of Tetraodontidae with the response surface methodology was reasonable and feasible, and it would provide a reference for the development and utilization of Tetraodontidae testis.

Key words: Takifugu Flavidus, protamine, response surface optimization

摘要： 为研究河鲀鱼精蛋白的制备工艺，以菊黄东方鲀（Takifugu Flavidus）精巢为原料，以鱼精蛋白提取率为指标，通过单因素试验研究NaCl溶液的pH、硫酸浓度、硫酸用量、提取温度、提取时间以及乙醇用量等单因素对鱼精蛋白提取率的影响，在此基础上，采用响应面法优化鱼精蛋白的提取工艺条件。结果显示，采用响应面法优化获得河鲀鱼精蛋白的最佳提取工艺条件为：NaCl溶液pH8.5，硫酸浓度0.6 mol/L，硫酸用量4.0倍体积，提取温度45℃，提取时间2.4 h，乙醇用量4倍体积，此时鱼精蛋白提取率达到19.07%。研究表明，响应面法对河鲀鱼精蛋白提取条件的优化方案合理可行，可为河鲀精巢的开发利用提供参考依据。

关键词: 菊黄东方鲀, 鱼精蛋白, 响应面优化